Home > 1.4 MW Low Pressure Waste Heat Boiler in the power plant

1.4 MW Low Pressure Waste Heat Boiler in the power plant

About Us

Zozen Boiler main products include gas&oil boiler, coal-fired boiler, biomass boiler, thermal fluid heater and other series of more than 400 varieties of specifications.
Contact us for Email:[email protected]

Our Main Product

our main boilers
wns boiler picture

1-20 ton gas/oil fired boiler

Price: $12000-$450000/set

Capacity: 1-20 ton/h

Pressure: 0.7-2 Mpa

Fuel: Nature gas, coke oven gas, biogas, methanol, liquid propane gas, diesel, heavy oil, light oil, crude oil, etc.

Industries: Heat supplying, chemical, food, textile, printing and dyeing, cigarettes and tobacco, fodder, pharmacy, building materials, brewery, rubber, hospital etc.

szs boiler picture

7-70 MW gas/oil fired hot water boiler

Price: $160000-$1800000/set

Capacity: 7-70 MW

Pressure: 1.0-1.6 Mpa

Fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, LPG, diesel, heavy oil, light oil, crude oil, etc.

Industries: Heat supplying, hospital, colleges and universities.

szl boiler picture

2.8-29mw coal fired boiler

Price: $70000-$750000/set

Capacity: 2.8-29mw

Pressure: 1.0-1.25 Mpa

Fuel: Bituminous coal, lean coal, anthracite

Industries: Heating, hotels, schools, hospitals

yyw boiler picture

horizontal thermal fluid heater

Price: $12000-$350000/set

Capacity: 700 - 14000 kw

Pressure: 0.8 - 1.0 Mpa

Fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

dzl boiler picture

1-20 ton biomass fired boiler

Price: $12000-$350000/set

Capacity: 1-20 ton/h

Pressure: 0.7-2.5 Mpa

Fuel: Biomass particles

Industries: Heating, chemical, food, tobacco, textile, printing and dyeing, feed, medicine, building material, wine, rubber, hospital

Enhanced power and heat generation from bio mass

biomass- burning plants, the power and heat generation can be substantially superheater for the low temperature steam from the waste boiler, an effective combined cycle . 1) 25 MW Back pressure steam turbine, 2) Generator, 3) 25 MW Gas turbine . a back pressure steam turbine with admission data 1.4 Mpa/ 350°C.

Study on the state of play of energy efficiency of

equipment, the investment cost of a pulverised coal-fired power plant increased from In waste incineration, fluidised bed technology is used in 15 - 30 MW heat and low pressure steam producing boilers. .. 1.4 GEOTHERMAL ENERGY .

Waste Heat Recovery - Optimising your energy

1.4 Heat integration analysis . . plants. The days of cheap energy are over, and energy efficiency is becoming a crucial . A key component in waste heat recovery is the heat exchanger. . in a plant. Consequently the boilers fuel consumption is reduced, as are .. supply of low-temperature waste heat, absorption chillers.

Waste Not, Want Not: Analyzing the Economic and

Waste-to-energy (WTE) technology burns municipal solid waste (MSW) in an environmentally safe combustion system to generate electricity, provide district heat, and reduce the need for .. 1.4.2 Power Generation . Boilers designed for thermal load only are typically low-pressure units in the range of 150 psig to.

Steam Plant Operation

power plant these include fuel and ash handling, handling of combus- to result in the generation of 1300 megawatts (MW) of electricity in an . plant because it adds additional steam energy to the low-pressure por- tion of the The boiler recovers the heat from combustion and generates steam . 1.4.1 Coal-fired boilers.

Cogeneration - Wikipedia, the free encyclopedia

All thermal power plants emit heat during electricity generation, which can be At smaller scales (typically below 1 MW) a gas engine or diesel engine may be A typical power generation turbine in a paper mill may have extraction pressures of The 45MW boiler uses waste wood biomass as energy source, and provides

District heating - Wikipedia, the free

1.4 District heat from combined heat and power or simple combustion . Waste heat from nuclear power plants is sometimes used for district heating. Also, the thermal efficiency of cogeneration plants is significantly lower if the cooling medium is .. buildings, including the State Capitol, using high-pressure steam boilers.

Combustion Turbines - Environmental Protection

cycle gas turbines used in power plants are available with efficiencies of over 40 percent (LHV). turbines is a chemical plant with a 25 MW simple cycle gas turbine supplying to be a combined heat and power (CHP) configuration if the waste .. The low pressure steam can extract the exhaust energy down to a HRSG.

power plant engineering | Hardian Bara -

Analysis of Steam Cycles 2.1 Steam Power Plant 38 2.2 Rankine Cycle 39 2.3 Carnot 61 2.12 Supercritical Pressure Cycle 66 2.13 Steam Power Plant Appraisal 66 2.14 .. At lower loads, the efficiency decreases and so the fuel consumption increases. 1.10 Plant net heat rate and incremental heat rate 1.4. 6 Economic

Geothermal Power Generation A Primer on Low

Geothermal power plants operating at low temperatures have low efficiency - often less Boiler. High pressure vapor. Low pressure vapor. Turbine. Low temperature 110 MW. Unfortunately, steam resources are the rarest of the all geothermal cooling water, is delivered to the cooling tower where the waste heat from

Demonstration of a Variable Phase Turbine Power

The heat source for the VPC power plant was geothermal brine at 235F from the separator of .. 1.4 Demonstration of Commercial Viability of Variable Phase Cycle megawatt geothermal plant at the Terra-Gen BLM East power plant, at Coso Geothermal .. High pressure refrigerant enters the top port, is expanded to low.

PREFEASIBILITY STUDY FOR BIOMASS POWER PLANT,

Jul 31, 2012 1.4.1 Part A - Dedicated Biomass to Power. 2.4 Selection of Suitable Technology Furnace and Boiler Plant . 3.2 Thermoflex Heat Balance Software . .. Appendix C. PFD for Scenario 2b 2x10 MW BFB Boiler Plant at Ohorongo . single feedwater heater that is fed by low pressure extraction steam

Review of Industrial Condensing Boilers -

Scale Biomass District Heating Plant (40 MW) In addition to waste heat recovery, condensing boilers can also be optimised for emission The condensing boiler requires a lower water return temperature and should be used in .. Condensing boilers run at a positive pressure with forced-draft power burners or.

Survey of modern power plants driven by diesel and

reciprocating engines of 1 MW output and more reaching the 5000 unit level, (10 GW), Two-stroke, low-speed diesel engine plants show the highest electric efficiencies, with . engine driven combined heat and power plant (in German: Motorenheizkraft- werk) additional fuel is burned in the waste heat steam boiler.

Biogas to Power | Green Brick Eco Solutions

With a small investment, you may also install a waste heat recovery boiler to recover the heat from the engine jacket cooling water,and produce low pressure steam for use electric power in a 1.4 MW gas engine with a waste heat recovery system. Technologies Ltd, Pune for their food processing plant at Abohar,Punjab.

Combined Heat and Power (CHP) | Whole Building

In a bottoming cycle system, also referred to as waste heat to power, fuel is combusted hot water, chilled water, Hot water, low-pressure and high-pressure steam Offset capital costs: CHP can be installed in place of boilers or chillers in new by $5-7 million after installing two CHP gas turbines in 2009 (PDF 1.4 MB) .

Pumps for the Production of Renewable Energy -

Figure 2 Simplified Fossil Fuel Power Generation Flow Diagram 2 .. natural gas-fired heat or a gas steam boiler/reheater is used. .. pressures than water, making it ideal for recovering energy from low- .. The generators produce about 1.4 mW, enough to power the biomass facility and another energy facility.

75. Power plant-20-years-gate-ies-ias-q-a by S K

Sep 7, 2015 S K Mondals Power Plant GATE, IES IAS 20 Years Question Answers Contents .. 1 2 2 1 1 = T p T p Where =1.4 air. (c) Decrease the capacity of condenser (d) Recovers the waste heat of boiler IES-12. .. In an ideal steam power cycle with the same inlet pressure, the low dryness

Brochure The Niederaussem Coal Innovation Centre

improve coal-based power generation in the interest of efficiency, the . pressure thanks to optimized cooling tower. + 1.4 %. Waste-gas heat utilization. + 0.9 %.

Technical Assessment of Tranche 1 Subprojects

Tranche 1 will upgrade four power plants and build three transmission lines. Their These advantages are (i) lower investment per unit of capacity, (ii) faster waste heat from the gas turbine is sent through a waste heat boiler, more . output of the Khulna power plant (225 MW in total) and deliver the power to the grid.

GET Support & Price

Please Feel free to give your inquiry in the form below.We will reply you in 24 hours