1-20 ton gas/oil fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2 Mpa
Fuel: Nature gas, coke oven gas, biogas, methanol, liquid propane gas, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, chemical, food, textile, printing and dyeing, cigarettes and tobacco, fodder, pharmacy, building materials, brewery, rubber, hospital etc.
7-70 MW gas/oil fired hot water boiler
Capacity: 7-70 MW
Pressure: 1.0-1.6 Mpa
Fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, LPG, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, hospital, colleges and universities.
2.8-29mw coal fired boiler
Pressure: 1.0-1.25 Mpa
Fuel: Bituminous coal, lean coal, anthracite
Industries: Heating, hotels, schools, hospitals
horizontal thermal fluid heater
Capacity: 700 - 14000 kw
Pressure: 0.8 - 1.0 Mpa
Fuel: natural gas, coke oven gas, bio-gas，liquid propane gas, diesel, heavy oil, light oil, crude oil
Industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries
1-20 ton biomass fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2.5 Mpa
Fuel: Biomass particles
Industries: Heating, chemical, food, tobacco, textile, printing and dyeing, feed, medicine, building material, wine, rubber, hospital
Industrial Boilers and Heat Recovery Steam
A few waste heat boiler specications provide the ue gas ow in volumetric units Lack of information on molecular weight or gas pressure can lead to incorrect I authored the Steam Plant Calculations Manual (Marcel Dekker, Inc.) . though several issues such as solid particle erosion, metallurgy of pressure parts,
Metallurgical Plant and Technology - Tenova
Apr 2, 2013 of the waste heat boiler must be planned Energy recovery potential for an EAF with 100 t tapping weight (MW 10.5. 22.7. Table 4. Energy recovery potential for an EAF with 150 t lower end of the pressure sliding range.
highly efficient electric smelters for the
platinum, silicon metal, ferrosilicon, ferronickel, calcium carbide, and copper. furnaces, rectangular furnaces, and gas cleaning and waste heat recovery, . Whilst energy consumption is lower in the case of PGM smelting, any reduction in power Platinum 2012. 220. SAF. 2 x 23 MW. Waste Heat. Boiler. Bag. Filter. Fan +.
Energy | Articles in Press | ScienceDirect.com
Heat transfer and pressure drop characteristics were estimated. Highlights. . The use of low-temperature waste heat from the CHP is described.
Patent EP1216286B1 - Energy recovery coke oven
Sep 15, 2010 A top charging plant for producing metallurgical coke by the The temperatures in the ovens tended to be low and as a result the and recover 100 MW of energy through a set of waste heat boilers to The waste gases in this system can be directly fed to the waste heat boilers without any prior treatment.
PINCH ANALYSIS :
Step 3: Identify major inefficiencies in the heat exchanger network . . . . . . . . . . . . . High and low temperature shift reactors (to maximize hydrogen yield) Q = 10.5 MW . recovery economically impractical due to metallurgical considerations. .. Process. Heating. Process. Steam. Waste Heat. Boiler. Syngas. Compressor.
Seamless Steel Tubes and Pipes for Boilers
pressure boilers, pressurized fluidized bed boilers, Please contact the Nippon Steel Sumitomo Metal Corporation office for the latest . facture small-diameter carbon steel tubes and low-alloy steel .. Heat exchanger tubes of waste to energy plant and black liquor . Hydrochloric acid resistance (10.5%80 HC).
Download full text
containing 6.0% of SO2 (8.5% leaving the waste heat boiler), is used to roasted ore so that it can be reduced to the metal by one of the .. the converter gases is reported to range from about 10.5 to Concentrates of sulfide ores can be leached under pressure of Kinneberg, D. A. and Messner, M. E., Use of oxygen in.
Association of Water Technologies Technical
heat transfer, which translates into better efficiency and prevention of tube failures. Dosages are lower than in low pressure boilers, but since many of these . As discussed above, sulfite does not passivate metal surfaces as well as other .. molecular weight of 380 and calcium carbonate has a molecular weight of 100,.
Metallurgical Furnaces, in: Ullmanns
Metallurgical Furnaces . in plain bearings with immersion or pressure- In iron ore reduction, low-iron alumina or . a) Bins for raw material; b) Waste-heat boiler; c) Aftercombustion chamber; d) Electrostatic precipitator; e) Rotary kiln; f) Coal Ni. Cu. Co. kW h/t ore. MW h/t Ni Cu. Sulfide ore. Manitoba. 10.5. 0.4. 0.2.
Coke | Article about coke by The Free Dictionary
In recovery coke plants the waste gas exits into a waste heat recovery boiler which of rocks caused by agents of heat, deforming pressure, shearing stress, hot, . The ash content of metallurgical coke should not exceed 910.5 percent. in comparison with coal coke, have a very low ash contentusually not more than
project design document - CDM - unfccc
May 25, 2008 Electrotherm 30 MW combined waste heat recovery and coal based captive power plant at Kutch . The project involves the installation of two WHR boilers including After Burner 10.5%. Detailed Project Report (DPR). Average kiln load factor .. P7 Captive Electricity generation from waste gas with lower
Best Available Techniques for Inorganic Acid and
Typical flow scheme for metallurgical gas clean up Simplified dual pressure flow diagram: medium concentration nitric acid . This is reported to achieve low levels of NO, emission without the .. te/day plant liberates over 60 MW of heat. gas is immediately cooled to around 420°C in a waste heat boiler; raising steam.
Designated National Authority for the CDM (UK DNA)
Apr 1, 2011 Limited. Fujian Cement 4 and 5 kilns Waste Heat 10.5 MW Wind Power Project at Kutch .. SASSA Low Pressure Solar Water Heater . Inner Mongolia Erdos Metallurgy Co., Ltd .. Biomass Residues in Boilers for Heat.
2. Description of Energy Production/Thermal Power
Mar 24, 2002 Self-Monitoring Manual for Energy Generating Plants 4.3 Impact of Solid Waste . 37 . Metallurgical Industry with specific reference to the two .. the furnace to below 1.8 MW/ m3 of furnace volume; otherwise, the tube boilers with high heat -release rates in the furnace. .. 86.0 10.5 3.0 0.05 0.05 0.2 0.2.
Reassessing the Efficiency Penalty from Carbon
Sep 30, 2015 Coal-fired boilers are likely to meet a growing demand for electricity in developing . (2009)(26), 10.5%-points, efficiency drop assumed based on existing a separate low-pressure boiler will be required to fully or partially meet the . of piping may preclude waste heat utilization in some CCS retrofits.
Get PDF (1176K) - Wiley Online Library
Hydrometallurgy of Nickel Concentrates and. Mattes . Atmospheric Pressure Carbonyl Process . . . . 72. 6.3.2. nickel consumption falling as low as 650 000 t / . 6.9 mW/cm .. 15. 110 000. Inco, Thompson. 10.5. 0.4. 73. 3. 50 000. Western Mining. 11.4. 0.85. 72. 5 . through waste-heat boilers to recover its sensible. 46.
Nuclear India | Department of Atomic Energy
RS is a large box type annular structure made from boiler quality carbon steel . Manufacture of components envisages extensive use of Manual Metal Arc (MMA) and a demonstration project coupled to 170 MW(e) PHWR station at Kalpakkam, which A 10 m3/d LTE desalination plant utilizing the waste heat of 400 KVA
Nickel and Cobalt Refining by QNI Pty. Ltd.
atmospheric pressure to selectively dissolve nickel and cobalt. The nickel metal/oxide calcine is further reduced to typically 97.5% Ni in travelling-belt . The dried ore is conveyed to a 2 kt surge bin, which feeds two parallel Hardinge 3 MW dry- plate heat exchangers using water-cooling, and then partially sulfided to
Millwright Apprenticeship. Related Training
following topics: fire and water tube types of boilers, construction, fittings, operation, cleaning, heat recovery systems, instruments and controls . 10.3. 10.4. 10.5. allEUSTTON. Canbustion. Canbustion. Canbustion. Canbustion METALLURGY. Lever .. Low-pressure boilers with small superheaters absorbed much of.